攪拌車變速箱維修要注意什么？
齒輪箱是混煉機的重要部件之一。正確操作變速箱可以節省車輛的油耗。齒輪箱的正確操作也可以延長其使用壽命。因此，在駕駛攪拌機時，一定要充分了解變速箱。在使用混凝土攪拌機齒輪箱的過程中，還需要注意一些事項。
Gearbox is one of the important parts of mixer. Correct operation of the transmission can save the fuel consumption of the vehicle. The correct operation of the gearbox can also prolong its service life. Therefore, when driving the mixer, be sure to fully understand the gearbox. In the process of using the gearbox of concrete mixer, some matters need to be paid attention to.
1?；旌掀鲹Q檔時，離合器必須完全分離，變速桿必須就位。
1。 When shifting the mixer, the clutch must be completely disengaged and the shift lever must be in place.
2。攪拌機的齒輪箱有高、低檔。停車時，變速箱換擋桿應置于低檔空檔位置。
2。 The gearbox of the mixer has high and low gears. When parking, the transmission shift lever should be placed in the low neutral position.
三。攪拌機在低速檔或倒檔時，應先停車后換檔，以免損壞變速器內部零件。在倒檔時，需要使用較大的檔位來克服倒檔的接地鎖止阻力。
Three. When the mixer is in low speed or reverse gear, stop it first and then shift it to avoid damaging the internal parts of the transmission. In reverse gear, a larger gear is required to overcome the grounding locking resistance of reverse gear.
四。變速器從低檔換到高檔時，不要跳檔，否則會影響同步器的使用壽命。
Four. When the transmission shifts from low gear to high gear, do not skip gear, otherwise the service life of the synchronizer will be affected.
5號。攪拌機下坡時，禁止換高、低檔。
Number five. When the mixer goes downhill, it is forbidden to shift to high or low gear.
六。攪拌機應根據路況在一檔或二檔啟動。
Six. The mixer shall be started in the first or second gear according to the road conditions.
7。攪拌機啟動前，應先松開制動器。制動閥接通后，只有當空氣壓力上升到所需壓力時，帶氣制動的攪拌機才能啟動。
7。 Release the brake before starting the mixer. After the brake valve is connected, the mixer with air brake can be started only when the air pressure rises to the required pressure.
8號。攪拌機在使用過程中，如有傳動異響、明顯重操等異?，F(xiàn)象，應立即停車檢查，排除故障后繼續行駛。
Number eight. In case of abnormal phenomena such as abnormal transmission noise and obvious re operation during the use of the mixer, stop the mixer immediately for inspection and continue driving after troubleshooting.
9號。如果在換檔時攪拌機不能掛檔，則必須檢查檔缸及其氣路，以確保輔助箱掛檔。
Number nine. If the mixer cannot be put into gear during gear shifting, the gear cylinder and its air circuit must be checked to ensure that the auxiliary box is put into gear.
10個。攪拌機的齒輪箱在“三包期”內一般不得擅自拆裝。
10. Generally, the gearbox of the mixer shall not be disassembled without authorization during the "three guarantee period".
攪拌機的變速箱要與發動機匹配，檔位要與轉速匹配，這樣才能在使用攪拌機時節省更多的燃油。
The gearbox of the mixer shall be matched with the engine, and the gear shall be matched with the speed, so as to save more fuel when using the mixer.
以上就是混凝土自上料攪拌車廠家http://pheenet.cn為大家介紹的內容，感謝您在百忙之中查看我公司的信息內容，如果您想要了解的更多，歡迎您來電進行咨詢!
The above is the concrete self loading mixer manufacturer http://pheenet.cn Thank you for checking the information of our company in your busy schedule. If you want to know more, you are welcome to call for consultation!
