介紹一下駕駛攪拌車的注意事項
相信我們對攪拌車都并不陌生。攪拌車是一種特殊車輛，并不是所有開車的司機都會開攪拌車，如果操作不當會引起翻車、液壓泵、馬達、減速機過快磨損甚出現嚴重后果。為了讓大家可以更的駕駛攪拌車，下面自上料攪拌車廠家就主要跟大家介紹一下駕駛攪拌車的注意事項。
I believe we are not strangers to mixer trucks. Mixer truck is a special vehicle. Not all drivers will drive the mixer truck. Improper operation will cause overturning, excessive wear of hydraulic pump, motor and reducer, and even serious consequences. In order to enable you to drive the mixer truck more safely, the following self loading mixer truck manufacturer will mainly introduce the precautions for driving the mixer truck.
1．起動攪拌車之前，應把攪拌筒操作手柄放在“停止”位置。
1. Before starting the mixer truck, put the operating handle of the mixing drum at the "stop" position.
2．攪拌車起動發動機后，應使攪拌筒在低速下轉動10分鐘左右，使液壓油溫升到20℃以上后方可工作。
2. After the engine of the mixer truck is started, the mixing drum shall be rotated at low speed for about 10 minutes, and the hydraulic oil can be operated only after the temperature rises above 20 ℃.
3．攪拌車在露天停放時，裝料前應將攪拌筒反轉，將積水和雜物排出，以保證混凝土的質量。
3. When the mixer truck is parked in the open air, the mixing drum shall be reversed before loading to drain the accumulated water and sundries to ensure the quality of concrete.
4．攪拌車在運輸混凝土?xí)r，要保證滑斗放置牢固，防止因松動造成擺動，在行進中打傷行人或影響其它車輛正常運行。
4. When transporting concrete, the mixer truck shall ensure that the sliding bucket is firmly placed to prevent swinging due to looseness, injuring pedestrians or affecting the normal operation of other vehicles.
5. 攪拌車裝運攪拌好的混凝土?xí)r，攪拌筒轉速為2-10轉/分，在運輸過程中，平坦路面上攪拌筒轉速保證在2-3轉/分，行駛在側傾坡度大于50的路面，或左右晃動較大的路面時，應停止攪拌旋轉，待路況好轉后再恢復攪拌旋轉。
5. When the mixer truck transports the mixed concrete, the rotation speed of the mixing drum is 2-10 rpm. During the transportation, the rotation speed of the mixing drum on the flat road surface shall be 2-3 rpm. When driving on the road surface with a side slope of more than 50 or the road surface with large shaking, the mixing and rotation shall be stopped, and the mixing and rotation shall be resumed after the road condition is improved.
6. 混凝土攪拌車運送混凝土的時間不能超過攪拌站規定的時間。運送混凝土途中，攪拌筒不得長時間停轉，以防混凝土產生離析現象。司機應時常觀察混凝土情況，發現異常及時通報調度室，申請做出處理。
6. The time for transporting concrete by concrete mixer truck shall not exceed the time specified by the mixing station. During the transportation of concrete, the mixing drum shall not be stopped for a long time to prevent segregation of concrete. The driver shall always observe the concrete condition, report any abnormality to the dispatching room and apply for handling.
7. 攪拌車車內裝有混凝土?xí)r，在現場停滯時間不得超過1小時，如超時應立即要求現場負責人給予及時處理。
7. When the mixer truck is loaded with concrete, the stagnation time at the site shall not exceed 1 hour. If it exceeds the time limit, the person in charge of the site shall be required to handle it in time.
希望以上的介紹可以對您有所幫助，如果您有需要的話，關注我們的網站http://pheenet.cn，時刻為您竭誠服務！
I hope the above introduction can help you. If you need it, please follow our website http://pheenet.cn Yes, we will always serve you wholeheartedly!
