混凝土自上料攪拌車冬季來臨要注意什么？
冬季的到來，溫度下降，所以在使用混凝土自上料攪拌車過程中需要多加注意一些事項，那么下面就跟著小編來了解了解吧。
With the arrival of winter, the temperature drops, so in the process of using concrete from the mixing truck need to pay more attention to some matters, then follow the small series to understand it.
混凝土自上料攪拌車開始行走前，所有的操縱桿、踏板和方向盤都應試一次，確保它們處于正常狀態后才能開始工作。確保使用適合當?shù)丨h(huán)境的防凍液來冷卻發動機。車輛長期不使用時，必須將防凍液排出，防止防凍液結垢。
All the joysticks, pedals and steering wheel should be tested once before the concrete mixing truck starts to run to ensure that they are in normal condition before starting to work. Be sure to use antifreeze suitable for local conditions to cool the engine. When the vehicle is not in use for a long time, antifreeze must be discharged to prevent antifreeze scaling.
控制輪胎充氣壓力，輪胎氣壓過高或過低都會導致輪胎過早磨損，嚴重影響輪胎的使用壽命。檢查水泵-風扇傳動皮帶，皮帶長時間使用后，皮帶會疲勞變形，降低冷卻效果。更換皮帶時，要注意型號和長度，正確調整松緊度。
Control tire inflation pressure, tire pressure too high or too low will lead to premature tire wear, seriously affect the service life of tires. Check the pump-fan drive belt, the belt will fatigue deformation after a long time of use, reduce the cooling effect. When replacing the belt, pay attention to the type and length, and adjust the tightness correctly.
清洗混凝土自上料攪拌車柴油箱吸油濾清器；混凝土自上料攪拌車水箱、散熱器表面的污染物；更換混凝土自上料攪拌車機油，更換機油和柴油濾清器；更換混凝土自上料攪拌車的變速箱油、油濾；檢查攪拌機發動機的氣門間隙。
Clean the oil suction filter of the diesel tank of the concrete self-feeding mixer; Remove the pollutants on the surface of water tank and radiator of concrete mixing truck; Replace the oil of the concrete self-feeding mixer, replace the oil and diesel oil filter; Replace the transmission oil and oil filter of the concrete self-feeding mixer; Check valve clearance of mixer engine.
混凝土自上料攪拌車廠家認為在冬季，要經常檢查和維護蓄電池的電解液和排氣孔。當溫度低于-30℃時，電池應采取保溫措施，以免凍裂。冬季要注意使用適合當?shù)氐蜏囟鹊娜加?、潤滑脂、潤滑油和液壓油（轉向系統和駕駛室升降機構用）。
Concrete mixing truck manufacturers think that in winter, to often check and maintain the battery electrolyte and exhaust. When the temperature is below -30℃， the battery should take heat preservation measures to avoid freezing and cracking. In winter, we should pay attention to the use of fuel oil, grease, lubricating oil and hydraulic oil suitable for local low temperature （steering system and cab lifting mechanism）。
根據混凝土自上料攪拌車使用區域的不同，請各位車友做好冬季使用的準備工作。這些準備工作在很大程度上決定了能否、可靠、長久地使用。更多內容的了解就來這里pheenet.cn了解吧。
According to the use area of the concrete mixing truck, please prepare for the use in winter. These preparations largely determine whether they can be used safely, reliably and for a long time. For more information, please visit pheenet.cn.
